The Yanmar diesel service included:
"Upon inspecting the engine it was found that the engine was in need of a complete service. Drained the coolant and engine oil. Removed all of the engine coolers, hoses and heat exchanger. Removed the cooler end caps and removed all debris and heavy build up. Reinstalled end caps and flushed coolers with Barnacle Buster 2 times for several hours, Prepped and painted all of the new hard piped oil and coolant lines. Disassembled the coolers, cleaned, painted and reassembled with new gaskets and O-rings, While engine accessories were removed the engine was cleaned, prepped, and repainted. reinstalled all engine coolers accessories and plumbing. Replaced the freshwater pump which was found to be leaking. Replaced the air intake heaters and air heater control module which was not working. Filled all fluids and checked for leaks. Cleaned up engine and deck areas."
Changed both the primary and secondary fuel filters and checked for prop... Test ran the engine to check for proper operation and leaks. Replaced the... sea strainer basket that was broken. Replaced the midships bilge pump float... a new pump base mounting bracket. Seatrialed vessel to check for leak... operation checked running temps which were at 156 degrees at full speed of 28 kts. 3200 RPM. Tested the jetsticks operatons functions. Tested neutral hover. Tested the autopilot function underway in helm mode."
"Performed valve adjustment on the engine. Turned the motor over by the ha... proper adjustment before test running the engine.
Jet Service included:
"Disassemble the entire jet unit. Inspected, cleaned, reprimed, and repainted all of the components. Inspected the wear ring and found it to have several gouges in it and the impeller to be worn. Suggested replacing the wear ring, aft nozzle bearing and servicing the impeller. Once the wear ring, insulator, bearing and impeller were repaired, reassembled and the zincs replaced as needed."
"Removed the impeller from its drive and sent out for repair"
"Removed the reverse buckets hyd. ram. Cleaned the mating surfaces and the ram. Reinstalled the ram with new sealing gaskets and 4200 sealant. Reconnected the hydraulic hoses and potentiometer. Ran the engine and manually operated the bucket ram with the hand valves to ensure the system bled out. Tested the neutral hovers operation."
Mechanical Service included:
"Flushed the domestic water tank and refilled with water and bleach. Ran bleached water thru the domestic water system then flushed the lines. Found the water heater to still be connected for service. Tested teh operationof the water heaterand all water systems. Head systems work but the head needs a new bowl seal kit. Primed and tested the air conditioning system. Bleached out the sinks and wet bath area. Cleaned the decks and cockpit areas."
Mechanical - Electrical Service included:
Cutoff and replaced the old corroded battery lugs from the existing cables. Crimped new battery lugs onto the existing battery cables. tested all electrical systems. Cabin/nav. lighting, inverter and charger. Tested the D.C. and A.C. systems on the main panel, and all functions at the helm console. Found the windlass not to operate (Repaired). The VHF radio does not operate. The Raymarine 4" display does not display depth. The radar display is very difficult to read. The horns compressor works but the trumpet does not operate properly. The oil exchanger pump leaks oil from the impeller housing.